MAN TGL recalls

Recall search results

← Back to search
Results: 18
Launch date Make / Model Concern Remedy Build range Manufacturer ref Vehicles
2025-07-16
MAN Truck and Bus Ltd - TGL
 8881TR TGL TGM TGS TGX . Inspect installation of universal joint of steering drive shaft Affected vehicles will be checked. Damaged components will be replaced if necessary and the steering shaft correctly installed. 2023-09-11 → 2025-01-09 8881TRen 132
2024-08-19
MAN Truck and Bus Ltd - TGL
 TGL TGM TGS TGX: The 24V sockets in the instrument panel can overheat. Check and replace the 24-volt socket. 2017-07-01 → 2023-07-01 8505TR 87
2022-01-19
MAN Truck and Bus Ltd - TGL
 FUEL HEATER MIGHT FAIL BECAUSE OF DAMAGE CAUSED BY HEAT TO ELECTRICAL CONNECTION Fit heat protection sleeve over fuel heater electrical connector and wiring. 2017-03-31 → 2021-05-07 TI 7740TRen 8878
2020-02-19
MAN - TGL, TGM, TGX, TGS
 Fehlerhafte Funktion der Fahrerhausverriegelung nach dem Zurückkippen kann zu verringerter Crashsicherheit und damit zu erhöhter Verletzungsgefahr führen Überprüfung und ggf. Austausch der Schließvorrichtung 2019-01-01 → 2020-01-01 7041TR 66
2018-07-20
MAN - TGL, TGX, TGM, TGS
 Federbügel zur Befestigung der Blattfedern können brechen. In der Folge kann es zu kritischen Fahrsituationen kommen. 1999-01-01 → 2018-01-01 TI6466TR 556
2017-01-11
MAN - TGL, TGA, TGM, TGS, TGX
 Mangelbehaftetes Relais der Kraftstofffilter-Heizung kann zum Brand führen. Die betroffenen Teile werden geprüft und mit einem brandhemmenden Schutzschlauch am Separfilterrelais ausgestattet. 2009-01-01 → 2015-01-01 TI566702 248
2016-02-08
MAN Truck and Bus Ltd - TGL
 RISK OF FIRE Recall the vehicles that are likely to be affected and check the relay for the fuel pre-filter heating. Where necessary replace the relay. The relay will only be re-sited if it is replaced. In all cases the protective sleeve must be fitted to the relay and wiring. - → - TI 566702 7323
2013-11-29
MAN Truck and Bus Ltd - TGL
 FRONT AXLE MAY BECOME INSECURE Recall all affected vehicles and replace the defective components. - → - 509204 392
2013-04-03
MAN Truck and Bus Ltd - TGL
 CONTROL OF VEHICLE MAY BE AFFECTED Recall all affected vehicles and disable the ESP system until a permanent fix is found. - → - TI 466605 12
2011-10-19
MAN Truck and Bus Ltd - TGL
 UNINTENTIONAL OPENING OF REAR DOOR Recall all affected vehicles and replace the lock operating mechanism in the door. - → - SI 411906 263
2010-06-09
MAN Truck and Bus Ltd - TGL
 DIRECTIONAL CONTROL COULD BE LOST Recall the affected vehicles and check for misalignment. If found replace steering shaft and check for damage on the steering gear shaft. Replace if damaged. - → - 4
2009-01-29
MAN Truck and Bus Ltd - TGL
 PROTENTIAL FOR STEERING TO FAIL. Recall the vehicles that are likely to be affected to replace the steering drag link. - → - 7
2008-11-07
MAN Truck and Bus Ltd - TGL
 REAR AXLE MAY BECOME INSECURE Recalled vehicles will have the subject shock absorbers replaced. - → - 288204 31
2007-12-17
MAN Truck and Bus Ltd - TGL
 REAR SEATBELTS MAY NOT FUNCTION CORRECTLY Recall affected vehicles replace seat belts and brackets and rework cladding elements at seat belts. - → - 245206 63
2007-11-01
MAN Truck and Bus Ltd - TGL
 STEERING MAY FAIL Recall affected vehiclescheck if joint located correctly if not reposition and fit and correctly torque new securing bolt. - → - 263204 2
2007-07-16
MAN Truck and Bus Ltd - TGL
 STEERING MAY FAIL Recalled vehicles will have the connection between the steering shafts checked. The components will be replaced if they show signs of damage. - → - 249304 34
2006-08-10
MAN Truck and Bus Ltd - TGL
 BRAKES MAY FAIL Recalled vehicles will have the subject bolts checked by the appliance of a test torque. - → - 208005 192
2006-06-02
MAN Truck and Bus Ltd - TGL
 STEERING MAY FAIL Subject vehicle will have the steering shafts checked and replaced as necessary. 2004-01-01 → 2006-05-17 185004en 1638