| Launch date | Make / Model | Concern | Remedy | Build range | Manufacturer ref | Vehicles |
|---|---|---|---|---|---|---|
| 2025-07-23 |
MAN Truck and Bus Ltd - TGX
TGX
|
TGS TGX bus/coach bus/coach chassis with Euro 6c engine D26: Renew oil filter lid. | The oil filter lid will be replaced. | 2017-01-26 → 2022-11-21 | 8062TRB TRUCK | 2068 |
| 2025-07-16 |
MAN Truck and Bus Ltd - TGX
TGX
|
8881TR TGL TGM TGS TGX . Inspect installation of universal joint of steering drive shaft | Affected vehicles will be checked. Damaged components will be replaced if necessary and the steering shaft correctly installed. | 2023-09-11 → 2025-01-09 | 8881TRen | 332 |
| 2025-07-15 |
MAN Truck and Bus Ltd - TGX
TGX
|
MAN TGS TGX Bus/Coach Bus /Coach Chassis with EURO6 C Engine – Renew Oil Filter Lid. | The oil filter lid will be replaced. | 2016-11-09 → 2020-05-18 | TI 7979TRG | 3407 |
| 2024-08-19 |
MAN Truck and Bus Ltd - TGX
TGX
|
TGL TGM TGS TGX: The 24V sockets in the instrument panel can overheat. | Check and replace the 24-volt socket. | 2017-07-01 → 2023-07-01 | 8505TR | 5607 |
| 2024-05-22 |
MAN Truck and Bus Ltd - TGX
TGX
|
TGS TGX: Retighten the hex lock nut of the drag link renew the drop arm and drag link if necessary | Check the bolt connection between the drop arm and drag link. Renew the drop arm and drag link if necessary. | 2020-07-13 → 2022-09-06 | 8272TR 8272TRb | 130 |
| 2024-02-09 |
MAN Truck and Bus Ltd - TGX
TGX
|
The nut of the screw connection between the steering pitman and drag link may not be tightened with the correct torque value. | Check the bolt connection between the steering pitman and drag link. Renew the steering pitman and drag link if necessary.� | 2023-04-06 → 2023-12-04 | TI 8365TR | 17 |
| 2022-01-19 |
MAN Truck and Bus Ltd - TGX
TGX
|
FUEL HEATER MIGHT FAIL BECAUSE OF DAMAGE CAUSED BY HEAT TO ELECTRICAL CONNECTION | Fit heat protection sleeve over fuel heater electrical connector and wiring. | 2017-03-31 → 2021-05-07 | TI 7740TRen | 8878 |
| 2021-07-26 |
MAN Truck and Bus Ltd - TGX
TGX
|
SPARE WHEEL CARRIER BOLTS NOT TIGHTENED CORRECTLY | Check all bolts fitted to the spare wheel carrier and tighten to 210nm. | 2021-04-17 → 2021-04-17 | 7571TR | 1 |
| 2021-07-06 |
MAN Truck and Bus Ltd - TGX
TGX
|
THE RIGHT LINKAGE ADJUSTERS ON THE REAR AXLE WERE MANUFACTURED INCORRECTLY | Replacement of the right linkage adjusters on the rear axle. | 2020-07-17 → 2020-12-17 | TI 7357TWa | 34 |
| 2021-05-13 |
MAN Truck and Bus Ltd - TGX
TGX
|
THE STEERING PROPSHAFT TO THE STEERING GEAR BOLT CONNECTION MAY NOT BE TIGHTENED CORRECTLY | If the hex socket fit bolt is present check for correct�torque and tighten if necessary. If the hex socket fit bolt is missing replace the lower part of the steering�propshaft�and both hex socket fit bolts. | 2020-03-21 → 2020-11-12 | TI 7344TWA | 115 |
| 2021-05-10 |
MAN Truck and Bus Ltd - TGX
TGX
|
A FRICTION WELD SEAM HAS BEEN OVER TORQUED AT THE MANUFACTURER OF THE STEERING PROPSHAFT AND INCORRECT GUIDE RINGS INSTALLED | Replace the steering propshaft and guide rings. | 2020-06-18 → 2020-06-29 | 7453 TR | 2 |
| 2020-12-14 |
MAN Truck and Bus Ltd - TGX
TGX
|
THE BRAKING EFFECT OF THE VEHICLE MAY BE DELAYED | Install the correct data file into the Electronic Control Unit. | 2012-09-14 → 2020-01-16 | TI 7313TR | 19 |
| 2019-01-11 |
MAN Truck and Bus Ltd - TGX
TGX
|
POTENTIAL FOR PREMATURE FAILURE OF PROP SHAFT UNIVERSAL JOINT | Replace propshaft and with a modified propshaft that can be greased at one end (Axle end) Propshaft to be replaced every 300000km | 2004-10-01 → 2016-05-13 | 6483TR | 394 |
| 2018-08-20 |
MAN Truck and Bus Ltd - TGX
TGX
|
PROPSHAFT MAY FAIL AND FALL OFF VEHICLE. | The remedy involves installing a prop shaft catcher to prevent failing prop shafts falling off. | 2004-10-01 → 2015-08-18 | 6115TRC | 394 |
| 2017-10-31 |
MAN Truck and Bus Ltd - TGX
TGX
|
STEERING MAY BECOME RESTRICTED | On affected vehicles Check coupling and where necessary replace with a correctly manufactured component. | 2016-12-07 → 2017-01-21 | 6294TR | 255 |
| 2016-02-08 |
MAN Truck and Bus Ltd - TGX
TGX
|
RISK OF FIRE | Recall the vehicles that are likely to be affected and check the relay for the fuel pre-filter heating. Where necessary replace the relay. The relay will only be re-sited if it is replaced. In all cases the protective sleeve must be fitted to the relay and wiring. | - → - | TI 566702 | 7323 |
| 2014-11-18 |
MAN Truck and Bus Ltd - TGX
TGX
|
PARKING BRAKE MAY APPLY INADVERTENTLY | Recall the vehicles that are likely to be affected and check the make and date of manufacture. Where necessary replace the manually operated parking brake valve. | - → - | 540805a | 1363 |
| 2014-11-18 |
MAN Truck and Bus Ltd - TGX
TGX
|
FIRE MAY OCCUR | Recall the vehicles that are likely to be affected and check the batch number of the flange for the oil pressure line on the turbo charger. Where necessary replace the flange and the oil pressure line. | - → - | 540900 | 165 |
| 2014-10-15 |
MAN Truck and Bus Ltd - TGX
TGX
|
TYRE TREAD COULD DETACH | Recall the vehicles that are likely to have tyres from the affected batches. All tyres fitted to the vehicle are to be checked including the spare. The tyres that are in the affected batches are to be changed out. | - → - | 535604b | 508 |
| 2014-07-22 |
MAN Truck and Bus Ltd - TGX
TGX
|
REDUCTION IN BRAKING PERFORMANCE | Recall the vehicles that are likely to be affected and fit new bracket and clamping straps for the compressed-air tanks at the rear. | - → - | 527904 | 195 |