Mercedes Sprinter recalls

Recall search results

← Back to search
Results: 279
Launch date Make / Model Concern Remedy Build range Manufacturer ref Vehicles
2020-12-23
MERCEDES-BENZ VANS UK LTD - SPRINTER
 ON AFFECTED VEHICLES FRONT AND REAR BRAKE HOSES MAY HAVE SUSTAINED AN OUTER CUT Check brake hose condition and renew if necessary. 2020-01-13 → 2020-10-01 SRV2020 1564
2020-12-16
MERCEDES-BENZ VANS UK LTD - SPRINTER 907
 VEHICLES WERE PRODUCED AND DELIVERED WITHOUT THE NECESSARY REAR UNDERRIDE GUARD Retrofit the rear underride guard on the affected vehicles. 2019-04-09 → 2020-03-03 SRV2019 37
2020-12-16
MERCEDES-BENZ VANS UK LTD - SPRINTER 910
 POSSIBLE DAMAGE AND SHORT CIRCUIT OF THE GLOW PLUG RELAY IN CERTAIN COLLISION SCENARIOS Retrofit a housing for the glow plug relay and install a pyrotechnic fuse on the affected vehicles 2018-04-04 → 2020-03-25 SRV2018 9372
2020-12-15
MERCEDES-BENZ - SPRINTER
 Incorrect headlamp leveling can cause glare for oncoming traffic. The incorrect holder is replaced by the correct holder with the intended rod length. 2020-01-01 → 2020-01-01 VS3HALTREG (8292254) 2
2020-11-04
MERCEDES-BENZ - SPRINTER
 Due to a production error, brake fluid may leak out and brake performance may be impaired as a result of possible material ageing of the brake hose. The condition of the brake hoses on the front and rear axles is checked and these are replaced if necessary. 2020-01-01 → 2020-01-01 VS3MONTLAU (4296091) 3029
2020-11-02
MERCEDES-BENZ - SPRINTER
 Cracks in the connection between the trailer coupling and the vehicle may cause the towbar to separate. The trailer hitch is replaced by a reinforced version. 2018-01-01 → 2018-01-01 VS3ANHAEBO (3191153) 100
2020-10-30
MERCEDES-BENZ - SPRINTER
 Die vorgeschriebene Dauerfestigkeit der Kugelkopfanhängerkupplung wird nicht eingehalten. Tausch der Kugelkopfkupplung der betroffenen Schmiedecharge. 2007-01-01 → 2020-01-01 NC3KUGELKO (3191099) und VS3KUGELKO (3191152) 249
2020-09-17
MERCEDES-BENZ - SPRINTER
 With certain configurations, it is possible that the vehicle was delivered without the intended rear underride guard, which can lead to an increased risk of injury in the event of an accident. Retrofitting a rear underride guard. 2018-01-01 → 2020-01-01 VS3UNTEFHI (8891072) 118
2020-09-15
MERCEDES-BENZ - SPRINTER, VIANO, V-KLASSE, VITO, CITAN
 Fehlerhafte Masseangaben im Fahrzeugschein können zu einer Überladung des Fahrzeugs führen. Erneuerung der Zulassungsdokumente sowie Überprüfung der Vorder- und Hinterachse bei Überladung (über 1,5 % des zulässigen Gesamtgewichtes). 2012-01-01 → 2017-01-01 VSXMBOSZU (5892257) 44
2020-09-03
MERCEDES-BENZ VANS UK LTD - SPRINTER 910
 THE ELECTRIC LINES ROUTED NEAR THE FRAME FOR THE ROTATING SEATS MAY GET JAMMED Correct the routing of the wiring harnesses of the rotating seats on the affected vehicles. 2018-10-31 → 2019-11-14 SRV2014 270
2020-09-03
MERCEDES-BENZ VANS UK LTD - SPRINTER 907
 THE ELECTRIC LINES ROUTED NEAR THE FRAME FOR THE ROTATING SEATS MAY GET JAMMED Correct the routing of the wiring harnesses of the rotating seats on the affected vehicles. 2018-10-31 → 2019-11-14 SRV2014 270
2020-08-14
MERCEDES-BENZ VANS UK LTD - SPRINTER
 INCORRECTLY IMPLEMENTED THREADED CONNECTION OF THE PROPELLER SHAFT INTERMEDIATE BEARINGS AT THE UNDERBODY Renew the screws of the propeller shaft intermediate bearing and tighten them with the specified torque in the affected vehicles. 2019-11-25 → 2019-12-02 SRV2009 4
2020-08-06
MERCEDES-BENZ - SPRINTER
 If an accident occurs, the glow timer output stage may be damaged, resulting in a short circuit and an increased risk of fire. Retrofit a cover housing for the glow timer output stage and a pyrotechnic fuse for your power supply. 2018-01-01 → 2020-01-01 VS3GLUZFWD (5499769) 13764
2020-08-05
MERCEDES-BENZ - SPRINTER
 The special signaling system can detach from the vehicle and enter the traffic area. 2019-01-01 → 2020-01-01 VS3ANBLAU 407
2020-07-09
MERCEDES-BENZ - SPRINTER
 Electrical wiring harnesses can become jammed and damaged in the seat swivel frames of the front seats. This can impair the function of the side airbags, increasing the risk of injury. The installation of the wiring harness is checked and the routing is secured using clips and/or cable ties. 2018-01-01 → 2020-01-01 VS3DREHSIK 1378
2020-06-23
MERCEDES-BENZ VANS UK LTD - SPRINTER 910
 THE OPERATING MANUAL DOES NOT SPECIFY CERTAIN CONDITIONS UNDER WHICH THE AUTOMATIC PARKING FUNCTION OF THE AUTOMATIC GEARBOX OPERATES Add a supplementary booklet with a correct description of the Auto-P function to the operating manual. 2018-04-04 → 2019-08-22 SRV2007 6475
2020-06-23
MERCEDES-BENZ VANS UK LTD - SPRINTER 907
 THE OPERATING MANUAL DOES NOT SPECIFY CERTAIN CONDITIONS UNDER WHICH THE AUTOMATIC PARKING FUNCTION OF THE AUTOMATIC GEARBOX OPERATES Add a supplementary booklet with a correct description of the Auto-P function to the operating manual. 2018-04-04 → 2019-08-22 SRV2007 6475
2020-06-04
MERCEDES BENZ BUS - SPRINTER
 POSSIBLE COLLISION BETWEEN BRAKE HOSES AND WHEEL ARCH LINER AT THE FRONT AXLE Check the position of the wing liner & modify as per working instructions. 2019-03-21 → 2019-10-02 T188.10X20097A 10
2020-05-28
MERCEDES-BENZ VANS UK LTD - SPRINTER 907
 THE WHEEL ARCH LINER ON THE FRONT AXLE COULD TOUCH AND CHAFE THE FLEXIBLE BRAKE HOSE Check the condition and clearance of the flexible brake hoses replacing them if necessary. Additionally the corresponding wheel arch liner will be modified to provide adequate clearance. 2018-03-22 → 2020-03-03 SRV2008 38865
2020-05-06
MERCEDES-BENZ - SPRINTER
 The intermediate drive shaft bearing on the vehicle substructure may not be bolted as specified. 2019-01-01 → 2019-01-01 VS3GELAGER (4190165) 3