| Launch date | Make / Model | Concern | Remedy | Build range | Manufacturer ref | Vehicles |
|---|---|---|---|---|---|---|
| 2025-01-20 |
TOYOTA (GB) PLC - AURIS
AURIS
|
High-Pressure Fuel Pump replacement on multiple models | A check of the high-pressure fuel pump and replace if necessary. | 2018-05-01 → 2018-11-30 | ZGGB1 (24SD-149) | 110 |
| 2023-11-20 |
TOYOTA (GB) PLC - AURIS
AURIS
|
Affected vehicles are fitted with a high-pressure fuel pump which over time could develop a crack which could lead to a fuel leak and a risk of a vehicle fire. | Check and replace high pressure fuel pump if necessary.� | 2017-11-06 → 2018-11-30 | 23SD-108 | 5440 |
| 2021-06-28 |
TOYOTA (GB) PLC - AURIS
AURIS
|
THE INSIDE OF THE HIGH PRESSURE FUEL PUMP MAY BE WORN OR DAMAGED OVER TIME DURING OPERATION | Inspect* and if necessary replace the high-pressure fuel pump. (*Based on engine variant and/or pump manufacturer/pump serial number.) | 2018-02-22 → 2018-11-22 | WGG27 | 5440 |
| 2021-05-31 |
TOYOTA (GB) PLC - AURIS
AURIS
|
THERE IS A POSSIBILITY THAT THE EXHAUST GAS RECIRCULATION COOLER COULD DEVELOP AN INTERNAL COOLANT LEAK | Replace the EGR cooler in all involved vehicles and if necessary replace the inlet manifold. | 2015-04-28 → 2018-05-04 | WGG13 | 24241 |
| 2020-07-27 |
TOYOTA (GB) PLC - AURIS HV
AURIS HV
|
UNDER CERTAIN CIRCUMSTANCES THE HYBRID UNIT MAY SHUT DOWN AND CAUSE LOSS OF MOTIVE POWER | Reprogram the Power Management ECU. | 2014-05-03 → 2018-11-30 | 20SMD-058 | 55724 |
| 2019-11-04 |
TOYOTA (GB) PLC - AURIS
AURIS
|
INCORRECTLY INSTALLED COVERS COULD PREVENT THE SEAT-MOUNTED SIDE AIRBAG FROM DEPLOYING | Inspect the covers installed on the front seats and replace any incorrectly installed covers | 2014-08-26 → 2018-11-30 | 19SMD-094 | 3887 |
| 2019-02-25 |
TOYOTA (GB) PLC - AURIS
AURIS
|
INCORRECT TIGHTENING TORQUE WAS POSSIBLY APPLIED DURING PREVIOUS INJECTOR REMOVAL OR REPLACEMENT | Check the injector clamp bolt torque and replace the parts if necessary. | 2015-05-06 → 2016-11-21 | 18SMD-133 | 321 |
| 2019-01-21 |
TOYOTA (GB) PLC - AURIS
AURIS
|
A POTENTIAL CRACK COULD DEVELOP IN THE FUEL EVAPORATIVE EMISSION CONTROL UNIT MOUNTED IN THE FUEL TANK | Replace the fuel tank emission control Canister. | 2007-07-02 → 2015-03-03 | 18SMD-071 | 85909 |
| 2019-01-14 |
TOYOTA (GB) PLC - AURIS HV
AURIS HV
|
VEHICLE MAY NOT ENTER FAILSAFE DRIVING MODE AS INTENDED IN RESPONSE TO CERTAIN HYBRID SYSTEM FAULTS | Reprogram the Power Management ECU. | 2010-05-26 → 2014-05-09 | 18SMD-088 | 55519 |
| 2018-07-31 |
TOYOTA (GB) PLC - AURIS
AURIS
|
REPLACEMENT AIRBAG INFLATOR INSTALLED IN AN INCORRECT ORIENTATION | Affected vehicles will have the inflator checked and corrected if it is necessary. | 2010-12-12 → 2016-10-04 | 18SMD-050 | 12182 |
| 2016-09-22 |
TOYOTA (GB) PLC - AURIS
AURIS
|
FUEL MAY LEAK / RISK OF FIRE | Recall the vehicles that are likely to be affected and replace the fuel suction plate sub-assembly. | 2006-04-27 → 2012-09-29 | TBA | 72891 |
| 2016-08-25 |
TOYOTA (GB) PLC - AURIS
AURIS
|
HEADLIGHT MAY MALFUNCTION | On affected vehicles replace headlamp units. | 2012-10-29 → 2015-04-15 | CGG54 | 14 |
| 2015-12-01 |
TOYOTA (GB) PLC - AURIS
AURIS
|
RISK OF FIRE | Inspect switch and apply coating. If switch indicates signs of malfunction it should be replaced. | 2005-06-13 → 2010-12-31 | TBA | 123306 |
| 2015-08-10 |
TOYOTA (GB) PLC - AURIS
AURIS
|
LOSS OF POWER | On affected vehicles reprogramme the Motor Generator and Power Management ECUs. | 2013-05-21 → 2014-05-06 | BGG34 | 24734 |
| 2015-06-15 |
TOYOTA (GB) PLC - AURIS
AURIS
|
PASSENGER SIDE AIRBAG MAY FAIL TO DEPLOY CORRECTLY | Recall the vehicles that are likely to be affected to replace the airbag. | 2010-04-12 → 2012-10-02 | BGG23 | 542751 |
| 2015-01-07 |
TOYOTA (GB) PLC - AURIS
AURIS
|
RISK OF FIRE | Depending vehicle diagnosis modify intercooler layout to improve air flow; upgrade ECU software; upgrade turbo charger and/or vacuum pump | 2008-04-27 → 2014-11-20 | 7884 | |
| 2012-10-26 |
TOYOTA (GB) PLC - AURIS
AURIS
|
FIRE MAY OCCUR | Recall all affected vehicles and check the switch. If the switch is not damaged a waterproof cover will be fitted. If the switch is damaged it will be replaced and a waterproof cover will be fitted. | 2006-09-14 → 2008-12-26 | 138049 | |
| 2012-09-12 |
TOYOTA (GB) PLC - AURIS
AURIS
|
REAR SUSPENSION ARM MAY SEPARATE | Recall all affected vehicles to check the torque on the arm. Where necessary the arm will be replaced. | 2007-02-07 → 2011-03-31 | 65863 | |
| 2010-02-06 |
TOYOTA (GB) PLC - AURIS
AURIS
|
ACCELERATOR PEDAL MAY FAIL TO RETURN TO IDLE | Recalled vehicles will have a precision-cut steel reinforcing bar fitted into the accelerator pedal assembly which will create a space in order to reduce the surface tension between the friction device and a component referred to as the pedal arm. The subject bar also strengthens the reaction force of the spring that returns the accelerator pedal to it's non-pressed position. | 2006-10-01 → 2010-01-05 | 174426 | |
| 2009-01-28 |
TOYOTA (GB) PLC - AURIS
AURIS
|
REAR BRAKE CALIPERS MAY DETACH | Recalled vehicles will have the near and offside brake caliper retaining bolts replaced. | 2008-01-02 → 2008-01-02 | 8 |