| Launch date | Make / Model | Concern | Remedy | Build range | Manufacturer ref | Vehicles |
|---|---|---|---|---|---|---|
| 2024-11-18 |
VOLVO TRUCKS - FL
FL
|
C0406 EMS ECM and ACM SW rollback. FL FE 3 | Install modified software. | 2014-12-01 → 2016-09-11 | C0406 | 16 |
| 2022-07-01 |
VOLVO TRUCKS - FL
FL
|
SOME STEERING SHAFTS WERE ASSEMBLED WITH AN INCORRECT COMPONENT | Check steering shaft and replace if necessary. | 2012-05-07 → 2021-10-17 | C0252 | 6 |
| 2019-09-17 |
VOLVO TRUCKS - FL
FL
|
DEGRADE OF EMISSIONS CONTROL COMPONENT | Check and If found then replacement of Silencer | - → - | M0079M0092M0097M0099 | 458 |
| 2017-04-24 |
VOLVO TRUCKS - FL3
FL3
|
RISK OF REAR UNDERRUN DETACHING | Recall all affected vehicles to check for damage replace the mounting bolts/nuts and torque them to the correct specification. | - → - | C0015 | 3 |
| 2017-02-03 |
VOLVO TRUCKS - FL
FL
|
REAR AXLE SUSPENSION MAY BECOME INSECURE | On affected vehicles check spring hangers and replace as required. | 2014-11-03 → 2016-06-03 | C3655 | 743 |
| 2014-07-14 |
VOLVO TRUCKS - FL
FL
|
TURBO PRESSURE HOSE MAY LEAK | Recall all affected vehicles and replace the turbo pressure hose. | - → - | C3231 | 2 |
| 2008-03-18 |
VOLVO TRUCKS - FL6
FL6
|
PRE-HEAT RELAY MAY STICK AND OVERHEAT | Recall all affected vehicles and disconnect the relay. | - → - | C0916 | 6130 |
| 2007-12-11 |
VOLVO TRUCKS - FL
FL
|
TORQUE REDUCTION VALUE LABEL MISSING ON ENGINE | Recalled vehicle will have the plate replaced. | - → - | C0892 | 44 |
| 2007-10-15 |
VOLVO TRUCKS - FL
FL
|
SPRING BRAKE CHAMBER OPERATION MAY BE AFFECTED IN LOW TEMPERATURES | Recall affected vehicles to drain the actuators. | - → - | 24 | |
| 2007-09-14 |
VOLVO TRUCKS - FL
FL
|
BRAKES MAY ENGAGE WHILST DRIVING | Recalled vehicles will have the spring brake chambers changed. | - → - | C0903 | 15 |
| 2007-06-01 |
VOLVO TRUCKS - FL
FL
|
BRAKES MAY FAIL TO OPERATE CORRECTLY | Recall affected vehicles remove brake chamber drain water and clean out. | - → - | c0822 | 39 |
| 2007-03-12 |
VOLVO TRUCKS - FL
FL
|
CAB MAY TILT UNEXPECTEDLY | Recalled vehicles will have the torque of the fixing checked and adjusted as necessary. | - → - | c0812 | 49 |
| 2004-11-02 |
VOLVO TRUCKS - FL6
FL6
|
POSSIBILITY OF A SHORT CIRCUIT OCCURRING | Affected vehicles will be fitted with a new cable within the voltage converter circuit. | - → - | C0541 | 86 |
| 2004-05-11 |
VOLVO TRUCKS - FL6
FL6
|
POSSIBILITY THAT THE AXLE MAY BECOME LOOSE IF THE U BOLT BREAK | Replace the front and rear axle U bolts and tighten to the appropriate torque. | - → - | C0503 | 1376 |
| 2001-10-01 |
VOLVO TRUCKS - FL
FL
|
BRAKE REACTION TIME | Recall affected vehicles for the fitment of larger diameter brake piping and connector between the front air tank and the footbrake valve. | - → - | C0347 | 208 |
| 2001-03-20 |
VOLVO TRUCKS - FL6
FL6
|
THE THROTTLE CONTROL BALL JOINT. | Recall affected vehicles and reposition the throttle linkage connections. Renew any worn throttle control ball joints. | - → - | 66 | |
| 2000-10-02 |
VOLVO TRUCKS - FL6
FL6
|
POSSIBLE INSECURITY OF STEERING ROD | Affected vehicles are being recalled for checking and where required retorqueing of both connections on the steering arm. | - → - | 393 | |
| 2000-03-17 |
VOLVO TRUCKS - FL6
FL6
|
BRAKE BACKPLATE MAY BECOME INSECURE | Recall affected vehicles and replace the studs with quality assured fixings. | - → - | 2 | |
| 2000-02-18 |
VOLVO TRUCKS - FL6
FL6
|
PARKING BRAKE MAY INADVERTENTLY BE ACTIVATED | Recall affected vehicles and remove the non-return valve from the inlet side to the outlet side of the 4-way protection valve. | - → - | 145 | |
| 1999-04-21 |
VOLVO TRUCKS - FL12
FL12
|
POSSIBILITY OF ENGINE OIL SPILLAGE | Likely to be affected vehicles to be recalled for checking and where necessary fit quality assured units. | - → - | 266 |