VOLVO V60 2020 recalls

Recall search results

← Back to search
Results: 21
Launch date Make / Model Concern Remedy Build range Manufacturer ref Vehicles
2025-06-23
VOLVO CAR - V60
 BCM2 SW – Safety Notice Install modified software via an Over the Air (OTA) update. 2019-06-07 → 2025-06-11 R10329 185
2025-03-24
VOLVO CAR - V60
 SPA1 Cell Modules Check and replace the HV Battery if necessary and install modified software. 2019-05-15 → 2021-12-01 R10312 353
2024-11-05
VOLVO CAR - V60
 BCM2 – Push Road A Volvo retailer will check and if necessary tighten the rod to correct specification. 2019-05-29 → 2020-08-08 R10289 22
2023-09-04
VOLVO CAR - V60
 During driving or idle the O-Ring may become twisted or break. Should this occur there could be an oil leak a message for low engine oil level displayed in the vehicle or an unusual smell in the cabin. In a worst case scenario this could cause a thermal event. Replace O-Ring 2020-12-02 → 2023-07-06 R10248 13701
2021-09-18
VOLVO CAR - V60
 POTENTIALLY INSUFFICIENT OR MISSING WELDING CONNECTION IN THE HYDRAULIC UNIT OF THE BRAKE SYSTEM Replace the Hydraulic Unit. 2019-12-02 → 2020-12-08 R10120 28
2021-09-18
VOLVO CAR - V60CC
 POTENTIALLY INSUFFICIENT OR MISSING WELDING CONNECTION IN THE HYDRAULIC UNIT OF THE BRAKE SYSTEM Replace the Hydraulic Unit. 2020-11-27 → 2020-12-03 R10120 28
2021-01-07
VOLVO CAR - V60CC
 VEHICLES MAY HAVE THE SUPPLEMENTARY RESTRAINT SYSTEM CONTROL UNIT INCORRECTLY TIGHTENED TO THE CAR BODY Inspect and tighten the SRS control unit. 2020-09-10 → 2020-09-22 R10068 704
2021-01-07
VOLVO CAR - V60
 VEHICLES MAY HAVE THE SUPPLEMENTARY RESTRAINT SYSTEM CONTROL UNIT INCORRECTLY TIGHTENED TO THE CAR BODY Inspect and tighten the SRS control unit. 2020-09-10 → 2020-09-22 R10068 704
2020-03-16
VOLVO CAR - V60CC
 SOFTWARE ISSUE MEANS THAT AUTOMATIC EMERGENCY BRAKE SYSTEM MAY NOT ENGAGE Affected vehicles must have new software downloaded 2019-09-21 → 2020-03-10 R29998 56385
2020-03-16
VOLVO CAR - V60
 SOFTWARE ISSUE MEANS THAT AUTOMATIC EMERGENCY BRAKE SYSTEM MAY NOT ENGAGE Affected vehicles must have new software downloaded 2019-01-21 → 2020-03-09 R29998 56385
2015-10-23
VOLVO CAR - V60CC
 ENGINE MAY FAIL Recall the vehicles that are likely to be affected and replace the engine. - → - R29579 5
2015-10-23
VOLVO CAR - V60
 ENGINE MAY FAIL Recall the vehicles that are likely to be affected and replace the engine. - → - R29579 5
2013-11-28
VOLVO CAR - V60
 LOSS OF POWER STEERING ASSISTANCE Recall the vehicles that are likely to be affected to replace the auxiliary drive belt and tensioner. - → - R29424 3134
2012-11-13
VOLVO CAR - V60
 TRIM PANEL MAY CAUSE INJURY DURING COLLISION Replace both trim panels and screws. - → - R89354 70
2012-09-14
VOLVO CAR - V60
 REDUCED BRAKING PERFORMANCE Inspect the brake booster vacuum line. If it is chafed then it should be replaced and routed correctly. If the line is not chafed it should re-routed to ensure no issues going forward. - → - R59345 3394
2012-04-24
VOLVO CAR - V60
 ENGINE MAY FAIL Recall the vehicles that are likely to be affected to replace the engine. - → - R29308 6
2012-03-07
VOLVO CAR - V60
 AIRBAGS MAY NOT DEPLOY IN A COLLISION Recall all affected vehicles for an inspection of the wiring harnesses and ensure that it is correctly routed and secured. If not then reroute and securing of the wiring harness. - → - R89297 9330
2011-07-20
VOLVO CAR - V60
 LOSS OF POWER STEERING FLUID Recall the affected vehicles for the replacement of the power steering return line. - → - R69238 213
2010-12-03
VOLVO CAR - V60
 FIRE MAY OCCUR Recall all affected vehicles and replace the high pressure pipes. - → - R29162 845
2010-11-26
VOLVO CAR - V60
 ENGINE MAY CUT OUT Recall the vehicles that are likely to be affected to upgrade the engine/transmission software. - → - R29159 64