VOLVO XC90 2023 recalls

Recall search results

← Back to search
Results: 22
Launch date Make / Model Concern Remedy Build range Manufacturer ref Vehicles
2025-06-23
VOLVO CAR - XC90
 BCM2 SW – Safety Notice Install modified software via an Over the Air (OTA) update. 2019-07-24 → 2025-06-11 R10329 1764
2024-03-11
VOLVO CAR - XC90
 Seat and Seat Belt Torque The solution is to check and adjust the torque. 2022-08-23 → 2023-07-09 R10267 4
2024-01-17
VOLVO - XC90
 Nicht der Spezifikation entsprechend befestigtes Gurtschloss der zweiten Sitzreihe kann sich im Falle eines Unfalls lösen und die Schutzwirkung des Gurtsystems beeinträchtigen. Bei den betroffenen Fahrzeugen muss die Befestigung des Gurtschlosses überprüft und ggf. modifiziert werden. 2023-01-01 → 2023-01-01 R10259 504
2023-12-08
VOLVO CAR - XC90
 The anchorage bolts for the second-row seat belts and seat belt buckles may not have been correctly secured. In a worst-case scenario this may not provide sufficient protection in the event of a collision. Inspect and re-install. 2014-01-12 → 2023-09-29 R10259 572
2023-01-24
VOLVO CAR - XC90
 There may be a potential software error in the brake control module. Update the brake control module software. 2022-10-11 → 2023-01-13 R10217 10197
2012-04-24
VOLVO CAR - XC90
 ENGINE MAY FAIL Recall the vehicles that are likely to be affected to replace the engine. - → - R29308 6
2011-05-16
VOLVO CAR - XC90
 POWER STEERING ASSISTANCE COULD BE LOST AND FLUID MAY LEAK Recall the vehicles that are likely to be affected to replace the internal pipe set. - → - R69217 4992
2010-10-18
VOLVO CAR - XC90
 WHEEL MAY BECOME LOOSE Recall all affected vehicles and replace the standard wheel bolts. - → - R79150 186
2010-07-13
VOLVO CAR - XC90
 FUEL MAY LEAK Recall affected for inspection of fuel pressure line and replacement if required. - → - R29116 466
2010-06-11
VOLVO CAR - XC90
 GEARBOX MAY JAM Recall the vehicles that are likely to be affected to check that the ball joint for the gear selector is properly secured. - → - R49111 6961
2010-04-22
VOLVO CAR - XC90
 FIRE MAY OCCUR Recall the vehicles that are likely to be affected to inspect and where necessary replace the fuel pressure line. - → - R29106 18
2009-12-02
VOLVO CAR - XC90
 LOSS OF POWER ASSISTANCE TO STEERING Recall the vehicles that are likely to be affected to fit a new pipe clamp and where necessary a new power steering hose. - → - R69034 6501
2008-05-08
VOLVO CAR - XC90
 VEHICLE MAY STALL Recalled vehicles will the engine mounting bracket screws replaced. - → - R28041 13
2008-03-05
VOLVO CAR - XC90
 STEERING POWER ASSISTANCE MAY FAIL Recalled vehicles will have the steering pressure hose secured to avoid possible engine cooling fan contact. - → - 3815
2007-12-10
VOLVO CAR - XC90
 CAN-BUS CONNECTION MAY BE AFFECTED Recalled vehicles will have the relevant software upgraded. - → - 245
2007-03-13
VOLVO CAR - XC90
 FIRE MAY OCCUR Recall the vehicles that are likely to be affected to fit an improved fan assembly. - → - 388
2007-02-13
VOLVO CAR - XC90
 ENGINE MALFUNCTION LIGHT MAY ILLUMINATE Recall the vehicles that are likely to be affected to replace the PCV nipple. - → - 1139
2006-05-10
VOLVO CAR - XC90
 STEERING MAY FAIL Recall the vehicles that are likely to be affected to replace both the nearside and the offside outer track rod ends. - → - r66021 18728
2005-11-21
VOLVO CAR - XC90
 BATTERY GROUND CABLE MAY SHORT CIRCUIT Recalled vehicles will have the distance between the battery positive cable checked and adjusted if the clearance is less than 4mm. - → - 911
2004-01-07
VOLVO CAR - XC90
 POSSIBLE FUEL LEAK FROM INJECTOR PIPES. Examine all potentially affected vehicles and replace any incorrectly fitted injector pipes. - → - 287